Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 1Model:ESC-42ST• DO NOT store or use gasoline or other fl am-mable vapors and liquids in the
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1310C. Clear SpaceWARNING! DO NOT place combustible objects in front of the fi replace or block l
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 11I. Before Lighting FireplaceBefore operating this fi replace for the fi rst time, have a qua
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1312J. Lighting Instructions (IPI)1. This appliance is equipped with an ignition device which
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 13Initial Break-in Procedure• The fireplace should be run three to four hours continuously on
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13143 3 Maintenance and Service A. Maintenance Tasks-HomeownerThe following tasks may be perfo
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 15B. Maintenance Tasks-Qualifi ed Service TechnicianThe following tasks must be performed by a
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1316Figure 3.1 IPI Pilot Flame Patterns• Inspect orifi ce for soot, dirt and corrosion. Verify o
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 17A. Typical Appliance SystemNOTICE: Illustrations and photos refl ect typical installations
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1318B. Design and Installation ConsiderationsHeat & Glo direct vent gas appliances are desi
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 195 5 Framing and Clearances A. Selecting Appliance LocationWhen selecting a location for t
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/132Listing Label Information/LocationModel Name: ___________________________________________ Dat
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1320CBDAB. Constructing the Appliance ChaseA chase is a vertical box-like structure built to en
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 21D. Mantel and Wall ProjectionsWARNING! Risk of Fire! Comply with all minimum clear-ances a
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1322E. Hearth ExtensionWARNING! Risk of Fire! Hearth extension required to protect combustible fl
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 23A. Vent Termination Minimum ClearancesRoof Pitch H (Min.) Ft.Flat to 6/12...
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1324Figure 6.3 Minimum Clearances for TerminationONPRQX= AIR SUPPLY INLETA = 12 inches...
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 25A. Approved PipeThis appliance is approved for use with Hearth & Home Technologies DVP
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1326E. Vent DiagramsWARNING! Risk of Fire. This appliance requires a mini-mum of 24 inches of ve
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 27H2 H1 V1 INSTALLED HORIZONTALLY 1. Top Vent - Horizontal TerminationV1H1Figure 7.3Figure 7
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13281. Top Vent - Horizontal Termination - (continued)Figure 7.5Three ElbowsH1V2H2V1V1H1V2 H2
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 292. Top Vent - Vertical TerminationNo ElbowFigure 7.6V1V1 = 50 ft. Max. (15.2 m)V1 = 3 ft.
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 3 Safety Alert Key:• DANGER! Indicates a hazardous situation which, if not avoided will re
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1330INSTALLEDHORIZONTALLYV2H2H1V1Three ElbowsV1H1H2V2Ht Max.2 ft 610 mm * * ** 7 in 178 mm3 ft 9
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 31A*BA. Pipe Clearances to CombustiblesWARNING! Risk of Fire! Maintain air space clearance t
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1332C. Install the Ceiling FirestopA ceiling fi restop MUST be used between fl oors and attics.•
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 33D. Install Attic Insulation ShieldWARNING! Fire Risk. DO NOT allow loose materials or insu
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1334CAUTION! Risk of Cuts, Abrasions or Flying Debris. Wear protective gloves and safety glasses
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 35B. Securing and Leveling the ApplianceWARNING! Risk of Fire! Prevent contact with:• Saggi
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/133610 10 Installing Vent Pipe A. Assemble Vent SectionsAttach Vent to the Firebox AssemblyN
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 37B. Assemble Slip Sections• Slide the inner fl ue of the slip section into the inner fl ue o
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1338D. Disassemble Vent Sections• Rotate either section (see Figure 10.10) so the seams on bot
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 39E. Install Metal Roof Flashing• See minimum vent heights for various pitched roofs (Figure
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/134 = Contains updated information.14 Appliance Setup A. Fixed Glass Assembly . . . . . . .
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1340SCREWSCAULKSTORM COLLAR(1 of 3)Figure 10.18 Figure 10.18 TERMINATION CAPG. Install Vert
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 41A. Fuel Conversion• Make sure the appliance is compatible with available gas types.• Conve
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1342A. Wiring RequirementsNOTICE: This appliance must be electrically wired and grounded in acco
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 43Figure 12.2 IPI Wiring DiagramACCENT LIGHT #1ACCENT LIGHT #2EMBER BULBS (1-4)TO JUNCTION B
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1344A. Mantel and Wall ProjectionsWARNING! Risk of Fire! Comply with all minimum clear-ances as
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 45B. Facing Material• Metal front faces may be covered with non-combustible materials only.
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1346D. Elevated Hearth SystemsUse the table below to identify the hearth system that will be us
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 4714 14 Appliance Setup Figure 14.1 Glass Top Tab Detail.A. Fixed Glass AssemblyWARNING! R
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1348B. Remove the Shipping MaterialsRemove shipping materials from inside or underneath the fi r
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 49F. Install Light Bulbs Note: Light bulbs are shipped in the installation manual bag.Ember
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 5B. Limited Lifetime Warranty4021-645F 02-18-13 Page 1 of 2Hearth & Home TechnologiesL
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1350G. Install RefractoryCAUTION: Refractory pieces are fragile! Carefully remove the refractory
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 51I. Mystic Ember PlacementWARNING! Risk of Explosion! Follow ember placement instructions
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1352J. Install the Log AssemblyGRATE: Locate the pilot assembly. The pilot assembly is denote
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 53LOG NUMBER 2 (SRV2146-702): Place Log #2 as shown. The groove on the bottom of Log #2 eng
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1354Figure 15Figure 14Figure 16.LOG NUMBER 6 (SRV2146-706): Place Log #6 onto grate and log #1.
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 55K. Ember/Mineral Wool PlacementWARNING! Risk of Explosion! DO NOT place embers directly ov
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1356Air Shutter SettingsNG LPESC-42ST 1-1/2 in. Fully OpenO. Air Shutter SettingAir shutter set
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 5715 15 Troubleshooting With proper installation, operation, and maintenance your gas applia
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1358Troubleshooting (continued)Symptom Possible Cause Corrective Action4. Pilot lights but conti
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 5916 16 Reference Materials Appliance Dimensions TableA. Appliance Dimension DiagramDimens
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/136B. Limited Lifetime Warranty (continued)4021-645F 02-18-13 Page 2 of 2WARRANTY CONDITIONS:
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1360B. Vent Components DiagramsFigure 16.2 DVP vent components 10-1/2 in.(267 mm)10-7/8 in.(27
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 61DVP-TRAP1DVP-TRAP2DVP-TRAPK2DVP-TRAPK1DVP-TRAPHorizontal Termination Cap15-1/8 in.(384 mm)1
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/136213-1/4 in.(337 mm)24-5/8 in.(625 mm)27-1/2 in.(699 mm)RF6MRoof Flashing Multi-pak31 in.(787
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 637-1/4 in.12 in.305 mm(184 mm)5-1/4 in.(133 mm)12-1/2 in.(318 mm)DVP-TVHWVerticalTermination
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1364Service PartsESC-42STBeginning Manufacturing Date: Dec 2008 Ending Manufacturing Date: Activ
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 65Service PartsESC-42STBeginning Manufacturing Date: Dec 2008 Ending Manufacturing Date: Acti
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1366Service PartsESC-42STBeginning Manufacturing Date: Dec 2008 Ending Manufacturing Date: Activ
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 67Service PartsESC-42STBeginning Manufacturing Date: Dec 2008 Ending Manufacturing Date: Acti
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/1368Heat & Glo, a brand of Hearth & Home Technologies 7571 215th Street West, Lakeville,
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 7C. BTU Specifi cationsMODELS: ESC-42ST, ESC-42STLPLABORATORY: Underwriters Laboratories, Inc
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/138H. Requirements for the Commonwealth of MassachusettsFor all side wall horizontally vented ga
Heat & Glo • ESC-42ST • 2146-900 Rev. Q • 4/13 9Figure 2.1 General Operating PartsB. Your FireplaceWARNING! DO NOT operate fi replace before
Comments to this Manuals